Solvent Storage Building Envelope & Steam Tunnel Repairs

SPECIFICATIONS 100% SUBMITTAL SOLVENT STORAGE BUILDING & STEAM TUNNEL REPAIRS USDA-ARS Eastern Regional Research Center 600 Mermaid Lane Wyndmoor, PA Prepared For: U.S. Department of Agriculture Agricultural Research Service (ARS) A-E Contract No.: 12305B21D0013 A-E Task Order No.: 1232SA25F0323 Prepared By: The Johnson-McAdams Firm, P.A. Greenwood, Mississippi April 2, 2026 -- 1 of 513 -- Solvent Storage Building Envelope & Steam Tunnel Repairs 3525 PROJECT TABLE OF CONTENTS DIVISION 01 - GENERAL REQUIREMENTS 01 00 01 01/20 WARRANTY OF CONSTRUCTION 01 00 11 06/20 GENERAL PARAGRAPHS 01 00 21 01/20 CONTRACTOR QUALITY CONTROL 01 01 00 8/10/22 GENERAL REQUIREMENTS 01 26 20 11/20, CHG 3: 02/23 WEATHER DELAYS 01 33 00 08/18 SUBMITTAL PROCEDURES 01 35 26 11/20, CHG 3: 02/22 GOVERNMENTAL SAFETY REQUIREMENTS 01 42 00 02/19 SOURCES FOR REFERENCE PUBLICATIONS 01 50 00 01/20 PROJECT CLOSEOUT 01 57 50 10/19 TEMPORARY ENVIRONMENTAL CONTROLS 01 74 19 02/19, CHG 3: 11/21 CONSTRUCTION WASTE MANAGEMENT AND DISPOSAL 01 78 23 08/15 OPERATION AND MAINTENANCE DATA DIVISION 02 - EXISTING CONDITIONS 02 41 00 08/22 DECONSTRUCTION DIVISION 03 - CONCRETE 03 01 00 02/18 REHABILITATION OF CONCRETE 03 30 53 05/14 MISCELLANEOUS CAST-IN-PLACE CONCRETE DIVISION 04 - MASONRY 04 03 00 08/25 CONSERVATION TREATMENT FOR PERIOD MASONRY DIVISION 05 - METALS 05 50 13 08/24, CHG 1: 08/25 MISCELLANEOUS METAL FABRICATIONS DIVISION 06 - WOOD, PLASTICS, AND COMPOSITES 06 10 00 08/16, CHG 3: 05/25 ROUGH CARPENTRY 06 73 01 08/23 FIBERGLASS REINFORCED PLASTIC (FRP) GRATING DIVISION 07 - THERMAL AND MOISTURE PROTECTION 07 11 13 08/23 BITUMINOUS DAMPPROOFING 07 13 53 08/25 ELASTOMERIC SHEET WATERPROOFING 07 14 00 08/23 FLUID-APPLIED WATERPROOFING 07 17 00 08/25 BENTONITE WATERPROOFING 07 62 13 08/25 COPPER SHEET METAL FLASHING AND TRIM 07 92 00 08/23 JOINT SEALANTS DIVISION 08 - OPENINGS 08 11 13 08/20, CHG 1: 08/25 STEEL DOORS AND FRAMES 08 71 00 02/16, CHG 4: 02/22 DOOR HARDWARE 08 91 00 08/20 METAL DOOR LOUVERS DIVISION 09 - FINISHES PROJECT TABLE OF CONTENTS Page 1 -- 2 of 513 -- Solvent Storage Building Envelope & Steam Tunnel Repairs 3525 09 90 00 02/21 PAINTS AND COATINGS 09 96 00 11/14 HIGH-PERFORMANCE COATINGS 09 97 23.17 08/16, CHG 1: 11/16 CORROSION INHIBITOR COATING OF CONCRETE SURFACES DIVISION 22 - PLUMBING 22 00 00 05/24, CHG 1: 11/24 PLUMBING, GENERAL PURPOSE DIVISION 23 - HEATING, VENTILATING, AND AIR CONDITIONING (HVAC) 23 30 00 02/25 HVAC AIR DISTRIBUTION DIVISION 26 - ELECTRICAL 26 20 00 05/25, CHG 1: 08/25 INTERIOR DISTRIBUTION SYSTEM DIVISION 31 - EARTHWORK 31 00 00 08/23 EARTHWORK DIVISION 32 - EXTERIOR IMPROVEMENTS 32 11 23 05/22 AGGREGATE BASE COURSE FOR FLEXIBLE PAVING 32 12 16.16 11/20 ROAD-MIX ASPHALT PAVING -- End of Project Table of Contents -- PROJECT TABLE OF CONTENTS Page 2 -- 3 of 513 -- Solvent Storage Building Envelope & Steam Tunnel Repairs 3525 SECTION 01 00 01 WARRANTY OF CONSTRUCTION 01/20 PART 1 GENERAL 1.1 WARRANTY OF CONSTRUCTION 1.1.1 General In addition to any other warranties set out elsewhere in this contract, the Contractor warrants that work performed under this contract conforms to the contract requirements and is free of any defect of equipment, material or design furnished, or workmanship performed by the Contractor or any of his subcontractors or suppliers at any tier. Such warranty shall continue for a period of one year from the date of final acceptance of the project. Under this warranty, the Contractor shall remedy at his own expense any such failure to conform or any such defect. In addition, the Contractor shall remedy at his own expense any damage to Government owned or controlled real or personal property, when that damage is the result of the Contractor's failure to conform to contract requirements or any such defect of equipment, material, workmanship, or design. The Contractor shall also restore any work damaged in fulfilling the terms of this clause. The Contractor's warranty with respect to work repaired or replaced hereunder will run for one year from the date of such repair or replacement. 1.1.2 Notification and Compliance The Government shall notify the Contractor in writing within a reasonable time after the discovery of any failure, defect, or damage. Should the Contractor fail to remedy any failure, defect, or damage described in paragraph 1.1.1 above within a reasonable time after receipt of notice thereof, the Government shall have the right to replace or repair and have the cost billed to the Contractor. 1.2 EXPRESSED WARRANTY In addition to the other rights and remedies provided by this clause, all subcontractors', manufacturers', and suppliers' warranties expressed or implied, respecting any work and materials shall, at the direction of the Government, be enforced by the Contractor for the benefit of the Government. In such case, if the Contractor's warranty under paragraph 1.1.1 above has expired, any suit directed by the Government to enforce a subcontractor's, manufacturer's, or supplier's warranty shall be at the expense of the Government. The Contractor shall obtain any warranties which the subcontractors, manufacturers, or suppliers would give in normal commercial practice. If so directed by the Contracting Officer, the Contractor shall require any such warranties to be executed in writing to the Government. 1.3 LATENT DEFECTS The Warranty specified herein shall not limit the Government's rights with respect to latent defects, gross mistake, or fraud. SECTION 01 00 01 Page 1 -- 4 of 513 -- Solvent Storage Building Envelope & Steam Tunnel Repairs 3525 PART 2 PRODUCTS Not used. PART 3 EXECUTION Not used. -- End of Section -- SECTION 01 00 01 Page 2 -- 5 of 513 -- Solvent Storage Building Envelope & Steam Tunnel Repairs 3525 SECTION 01 00 11 GENERAL PARAGRAPHS 06/20 PART 1 GENERAL 1.1 DESCRIPTION OF WORK 1.1.1 Work To Be Done The work to be done con…