Z1DA--642-22-104 | Upgrade Substation Building 2 Phase 1 | Kevin Rodgers | NCO 4 Construction East (VA-26-00030476)

Office of Facilities Management DEPARTMENT OF VETERANS AFFAIRS SUBSTATION UPGRADE BUILDING 2 – PHASE 1 CORPORAL MICHAEL J. CRESCENZ MEDICAL CENTER- VA ADMINISTRATION 3900 Woodland Avenue Philadelphia, Pennsylvania 19104 Bid Documents Project No. 642-22-104 Specification October 21, 2024 A Design Group, LLC Art-Architecture-Engineeing 2787 Hill Road Vienna, VA 22181 Phone: (703) 938-5226 -- 1 of 597 -- Substation Upgrade Building 2 VA Project # 642-22-104 VA-Medical Center, Philadelphia, PA Bid Documents 06-01-22 00 01 10-1 TABLE OF CONTENTS Section 00 01 10 SECTION NO. DIVISION AND SECTION TITLES DIVISION 00 - SPECIAL SECTIONS 00 01 15 List of Drawing Sheets DIVISION 01 - GENERAL REQUIREMENTS 01 00 00 General Requirements 01 32 16.15 Project Schedules (Small Projects-Design/Bid/Build) 01 33 23 Shop Drawings, Product Data, and Samples 01 35 26 Safety Requirements 01 42 19 Reference Standards 01 45 00 Quality Control 01 45 29 Testing Laboratory Services 01 57 19 Temporary Environmental Controls 01 58 16 Temporary Interior Signage 01 74 19 Construction Waste Management 01 77 00 Closeout Procedures 01 81 13 Sustainable Construction Requirements 01 91 00 General Commissioning Requirements DIVISION 02 – EXISTING CONDITIONS 02 41 00 Demolition DIVISION 03 – CONCRETE 03 30 53 (Short-Form) Cast-in-Place Concrete DIVISION 04 – MASONRY – Not Used DIVISION 05 – METALS 05 40 00 Cold-formed metal framing DIVISION 06 – WOOD, PLASTICS AND COMPOSITES – Not Used DIVISION 07 - THERMAL AND MOISTURE PROTECTION 07 84 00 Firestopping 07 92 00 Joint Sealants DIVISION 08 - OPENINGS 08 11 13 Hollow Metal Doors and Frames DIVISION 09 – FINISHES 09 29 00 Gypsum Board 09 91 00 Painting -- 2 of 597 -- Substation Upgrade Building 2 VA Project # 642-22-104 VA-Medical Center, Philadelphia, PA Bid Documents 06-01-22 00 01 10-2 SECTION NO. DIVISION AND SECTION TITLES DIVISION 10 – SPECIALTIES – Not Used DIVISION 11 – EQUIPMENT – Not Used DIVISION 12 – FURNISHINGS – Not Used DIVISION 13 - SPECIAL CONSTRUCTION – Not Used DIVISION 14– CONVEYING EQUIPEMENT - Not Used DIVISION 21- FIRE SUPPRESSION 21 13 13 Wet-Pipe Sprinkler Systems DIVISION 22 – PLUMBING – Not Used DIVISION 23 – HEATING, VENTILATING, AND AIR CONDITIONING (HVAC) 23 05 12 General Motor Requirements for HVAC and Steam Generation Equipment 23 05 41 Noise and Vibration Control for HVAC Piping and Equipment 23 05 93 Testing, Adjusting, and Balancing for HVAC 23 07 11 HVAC and Boiler Plant Insulation 23 08 00 Commissioning of HVAC Systems 23 09 23 Direct-Digital Control System for HVAC 23 21 13 Hydronic Piping 23 31 00 HVAC Ducts and Casings 23 37 00 Air Outlets and Inlets 23 40 00 HVAC air cleaning devices 23 73 00 Indoor Central Station Air Handling Units 23 82 16 Air Coils DIVISION 25 – INTEGRATED AUTOMATION – Not Used DIVISION 26 – ELECTRICAL 26 05 11 Requirements for Electrical Installations 26 05 13 Medium Voltage Cables 26 05 19 Low-Voltage Electrical Power Conductors and Cables 26 05 26 Grounding and Bonding for Electrical Systems 26 05 33 Raceway and Boxes for Electrical Systems 26 05 73 Overcurrent Protective Device Coordination Study 26 08 00 Commissioning of Electrical Systems 26 11 16 Secondary Unit Substations 26 13 16 Medium-Voltage Fusible Interrupter Switches 26 22 00 Low-Voltage Transformers 26 24 13 Distribution Switchboards 26 24 16 Panelboards 26 25 11 Busways 26 27 26 Wiring Devices 26 29 11 Motor Controllers -- 3 of 597 -- Substation Upgrade Building 2 VA Project # 642-22-104 VA-Medical Center, Philadelphia, PA Bid Documents 06-01-22 00 01 10-3 SECTION NO. DIVISION AND SECTION TITLES 26 29 21 Enclosed Switches and Circuit Breakers 26 36 23 Auto Transfer Switches 26 43 13 Surge Protection Devices 26 51 00 Interior Lighting DIVISION 27 – COMMUNICATIONS – Not Used DIVISION 28 – ELECTRONIC SAFETY AND SECURITY 28 05 13 Conductors and Cables for Electronic Safety and Security 28 05 26 Grounding and Bonding for Electronic Safety and Security 28 05 28.33 Conduits and Backboxes for Electronic Safety and Security 28 31 00 Fire Detection and Alarm DIVISION 32 – EXTERIOR IMPROVEMENTS 32 31 13 Chain Link Fences and Gates -- 4 of 597 -- Substation Upgrade Building 2 VA Project # 642-22-104 VA-Medical Center, Philadelphia, PA Bid Documents 00 01 15 - 1 SECTION 00 01 15 LIST OF DRAWING SHEETS The drawings listed below accompanying this specification form a part of the contract. Drawing No. CS-01 A-100 A-101 A-102 A-103 AS-001 2-LS-00.2 M-001 MD-101 MH-101 MJ-101 MK-101 E-001 E-100 E-101 E-102 E-103 E-104 E-105 E-106 Title COVER SHEET ARCHITECTURAL PARTIAL GROUND FLOOR-ELECTRICAL ROOM-DEMOLITION PLAN PARTIAL GROUND FLOOR-ELECTRICAL ROOM-NEW WORK PLAN PARTIAL SUB-BASEMENT AND INTERSTITIAL FLOOR PLANS-ICRA WALL LOCATION DETAILS EGRESS AND LIFE SAFETY PLAN BUILDING 2 BASEMENT/GROUND FLOOR-LIFE SAFETY PLAN (EXISTING DRAWING REFERENCE ONLY) MECHANICAL MECHANICAL COVER SHEET ELECTRICAL ROOM-DEMOLITION WORK-MECHANICAL ELECTRICAL ROOM-NEW WORK-MECHANICAL MECHANICAL SCHEDULES AND CONTROLS MECHANICAL DETAILS ELECTRICAL ELECTRICAL COVER SHEET PARTIAL GROUND FLOOR-ELECTRICAL ROOM-DEMOLITION PLAN PARTIAL SITE UTILITY PLAN PARTIAL GROUND FLOOR-ELECTRICAL ROOM-LIGHTING- NEW WORK PLAN PARTIAL GROUND FLOOR-ELECTRIC ROOM-EQUIPMENT LAYOUT-NEW WORK PLAN PARTIAL GROUND FLOOR-ELECTRICAL ROOM-FIRE ALARM NEW WORK PLAN PROPOSED MV CABLES ROUTING PLAN SINGLE LINE RISERS-DEMOLITION -- 5 of 597 -- Substation Upgrade Building 2 VA Project # 642-22-104 VA-Medical Center, Philadelphia, PA Bid Documents 00 01 15 - 2 E-107 SINGLE LINE RISERS-SUBSTATION #1, #2 AND “T”- NEW WORK E-108 SCHEDULES AND EQUIPMENT ELEVATIONS FIRE PROTECTION FP-001 FIRE PROTECTION COVER SHEET FPD-101 ELECTRICAL ROOM-DEMOLITION WORK-FIRE PROTECTION FP-101 ELECTRICAL ROOM-NEW WORK-FIRE PROTECTION - - - END - - - -- 6 of 597 -- Substation Upgrade Building 2 VA Project # 642-22-104 VA-Medical Center, Philadelphia, PA Bid Documents 01 00 00 -1 SECTION 01 00 00 GENERAL REQUIREMENTS GENERAL 1.1 SAFETY…